Simplicity 520M Spezifikationen

0 5implicilq®TM0AATOUAL520M ModelsMfg. No. Description1693643 520M, 5HP Snowthrower, Manual Start1693645 520M, 5HP Snowthrower, Manual Start (CE)85630

Cofltrols& OperatmENGINE & STARTING CONTROLSNOTE: Throttle = This snow thrower does NOT have athrottle for controlling operating speed of engi

Controls& OperationGENERAL OPERATIONCHECKS BEFORE EACH START-UP..Make sure all safety guards are in place and all nuts,bolts and clips are secure.

Cofltrols& OperatmFUEL AND OIL MIXTUREThe snowthrower uses a two cycle engine that requires amixture of fuel (gasoline) and oil for lubrication of

Controls& OperationSTARTING THE ENGINENOTE: The snow thrower engine is designed to operateat cold temperatures. Avoid operating the snow thrower f

Cofltrols& OperatmOPERATING THE SNOWTHROWERBefore operating snowthrower, review the Checks BeforeEach Use under General Operation on page 8 of thi

Removing Belt CoverIn order to perform proper lubrication, it is necessary toremove the Belt cover from the lower left of thesnowthrower.1. Remove the

TroubleshootJfig& ServiceTROU BLESHOOTINGPossible CauseProblemEngine fails to startEngine starts hard or runs poorlyUnit does not throw snow1. Key

TroubJeshootJflg& ServiceLift Coverfrom Rearof unit\Align rear Insert fronttabs & side of tabs first whencover when reinstallingreinstalling,

Tpoubleshootifl8& SepviceREPLACING THE DRIVE BELT1. Remove Engine Key from switch.2. Remove belt and engine covers.3. Move the Auger Control on th

$pecificaUoflsNOTE: Specifications are correct at time of printing and are subject to change without notice.* Actual sustained equipment horsepower wi

(ableofContentsSafety Rules & InformationGeneral ... 2Slope Operation ...

MANUFACTURING, INC.500 N Spring Street / PO Box 997Port Washington, Wl 53074-0997www.simplicitymfg.com© Copyright 2003, Simplicity Manufacturing, Inc.

Readthesesafetyrulesandfollowthemclosely.Failuretoobeytheserulescouldresultinlossofcontrolof unit,severepersonalinjuryordeathtoyou,orbystanders,ordama

Safety RulesCHILDRENTragic accidents can occur if the operator is not alert to thepresence of children. Children are often attracted to theunit and th

Safety RulesANSI B71.3-1995 WARNINGSTraining1. Read the operating and service instruction manualcarefully. Be thoroughly familiar with the controls an

Product IdefltificatioflManufacturing, Inc,W] 53074-0997 U,S,A,SERIAL169XXXXNorth AmericaniVlodelsMfg. Ng'._' 169XXXX _' _"se,al_\

SafetyRules& informationSAFETY DECALSSafety warning decals are placed at strategic locations on the snowthrower as a constant reminder to the oper

Figure 1. Assembly of Discharge ChuteA. Discharge Chute D, NutsB. Carriage Bolts E. Rotating RingC. WashersTOOLS REQUIRED• Socket or Wrench Set• Pair

SNOWTH ROWER CONTROLSAuger ControlA. Auger Control =This control engages and disen-gages the auger. Pull the control back against handleto engage the